3 electronic solutions division interconnect solutions http://www.3m.com/interconnects/ 3m and metpak are trademarks of 3m company. for technical, sales or ordering information call 800-225-5373 3m ? cp2 press-fit socket 2 mm type b, 95, 110, and 125 signal contacts, right angle cp2 series 25 mm basic system unit ? 50 mm module ? designed according to iec 61076-4-101 and iec 60352-5 ? standards 2 mm grid spacing allows for high signal density at low cost ? eye of the needle compliant pin press-ft design helps ? reduce manufacturing time and cost additional grounding row available for improved ground ? bounce and emi immunity mates with 5 row 3m ? ? metpak ? hm, and cp2 headers end-to-end stackable with 5 row 3m ? ? metpak ? hshm, hm, and cp2 sockets see regulatory information appendix (ria) for chemical ? compliance information date modifed: february 29, 2008 ts-2268-a sheet 1 of 2 physical insulation: material: high temperature thermoplastic (lcp) flammability: ul94v-0 contact: material: copper alloy plating: see ordering information mechanical mating force: 0.75n/pin withdrawl force: 0.15n/pin mating and un-mating operations: 50 electrical electrical load: 1.0 a at +70c contact resistance: 20 m insulation resistance: 10,000 m test voltage: 750 vac rms environmental temperature rating: -55c to +125c pcb data recommended pcb plated through hole: 0.60.05 mm drill hole diameter: 0.70.02 mm hole platings cu 25~50 m, sn or snpb<10 m pcb thickness: 1.4-4.2 mm press-in force: 204 n/pin on nominal hole diameter retention force: 13.5 n/pin on nominal hole diameter
3 electronic solutions division interconnect solutions http://www.3m.com/interconnects/ 3m and metpak are trademarks of 3m company. for technical, sales or ordering information call 800-225-5373 3m ? cp2 press-fit socket 2 mm type b, 95, 110, and 125 signal contacts, right angle cp2 series ts-2268-a sheet 2 of 2 ordering information cp2-sbxxx-x1-xxxx ? this diagram serves only for part number descriptive defnitions. please contact your local sales representative for customer specific proguct configurations. " a " " b " " b " signal contact quantity dimension a dimension b 95 38.00 36.00 110 44.00 42.00 125 50.00 48.00 reccommended pcb layout number of signal contacts: 095,110 and 125 shield options: g= upper shield blank= no shield plating options tg30= 30~40 gold contact area 100~200 bright tin-lead 50~80 nickel underplate (ria e2 &c2 apply) fj= 10~20 gold contact area 200~300 matte tin 50~80 nickel underplate (ria e1 &c1 apply) kr= 30~40 gold contact area 200~300 matte tin 50~80 nickel underplate (ria e1 &c1 apply) mm [inch] 0.13 1 0.3 tolerance unless noted 0. .0 .00 mm [ ] dimensions for reference only
regulatory information appendix 3m electronic solutions division/interconnect europe appendix e1: european union rohs directive 2002/95/ec, restriction of the use of certain hazardous substances in electrical & electronic equipment, as amended by eu commission decision 2005/618/ec. this product is rohs compliant 2005/95/ec. rohs compliant 2005/95/ec means that the product or part (product) does not contain any of the substances in excess of the maximum concentration values in eu directive 2002/95/ec, as amended by commission decision 2005/618/ec, unless the substance is in an application that is exempt under eu rohs. unless otherwise stated by 3m in writing, this information represents 3ms best knowledge and belief based upon information provided by third party suppliers to 3m. in the event any product is proven not to conform with 3ms regulatory information appendix, then 3ms entire liability and buyers exclusive remedy will be in accordance with the warranty stated below. appendix e2: european union rohs directive 2002/95/ec, restriction of the use of certain hazardous substances in electrical & electronic equipment, as amended by eu commission decision 2005/618/ec. this product contains lead in the compliant pin area in excess of the maximum concentration value allowed but is compliant by exemption under eu commission decision 2005/747/ec. rohs compliant 2005/95/ec means that the product or part (product) does not contain any of the substances in excess of the maximum concentration values in eu directive 2002/95/ec, as amended by commission decision 2005/618/ec, unless the substance is in an application that is exempt under eu rohs. unless otherwise stated by 3m in writing, this information represents 3ms best knowledge and belief based upon information provided by third party suppliers to 3m. in the event any product is proven not to conform with 3ms regulatory information appendix, then 3ms entire liability and buyers exclusive remedy will be in accordance with the warranty stated below. appendix e3: european union rohs directive 2002/95/ec, restriction of the use of certain hazardous substances in electrical & electronic equipment as amended by commission decision 2005/618/ec. this product contains lead in the solder tail area in excess of the maximum concentration value allowed . unless otherwise stated by 3m in writing, this information represents 3ms best knowledge and belief based upon information provided by third party suppliers to 3m. in the event any product is proven not to conform with 3ms regulatory information appendix, then 3ms entire liability and buyers exclusive remedy will be in accordance with the warranty stated below. appendix e4: european union rohs directive 2002/95/ec, restriction of the use of certain hazardous substances in electrical & electronic equipment, as amended by eu commission decision 2005/618/ec. this product contains decabde in the insulating material in excess of the maximum concentration value allowed but is compliant by exemption under eu commission decision 2005/717/ec. rohs compliant 2005/95/ec means that the product or part (product) does not contain any of the substances in excess of the maximum concentration values in eu directive 2002/95/ec, as amended by commission decision 2005/618/ec, unless the substance is in an application that is exempt under eu rohs. unless otherwise stated by 3m in writing, this information represents 3ms best knowledge and belief based upon information provided by third party suppliers to 3m. in the event any product is proven not to conform with 3ms regulatory information appendix, then 3ms entire liability and buyers exclusive remedy will be in accordance with the warranty stated below. ria-2217b-d
appendix e5: european union rohs directive 2002/95/ec, restriction of the use of certain hazardous substances in electrical and electronic equipment, as amended by eu commission decision 2005/618/ec. this product contains lead in excess of the maximum concentration value allowed but is compliant by exemption under item 6 of the annex to the directive. rohs compliant 2005/95/ec means that the product or part (product) does not contain any of the substances in excess of the maximum concentration values in eu directive 2002/95/ec, as amended by commission decision 2005/618/ec, unless the substance is in an application that is exempt under eu rohs. unless otherwise stated by 3m in writing, this information represents 3ms best knowledge and belief based upon information provided by third party suppliers to 3m. in the event any product is proven not to conform with 3ms regulatory information appendix, then 3ms entire liability and buyers exclusive remedy will be in accordance with the warranty stated below. china appendix c1: china rohs electronic industry standard of the peoples republic of china, sj/t11363-2006, requirements for concentration limits for certain hazardous substances in electronic information products. this symbol, per marking for the control of pollution caused by electronic information products, sj/t11364-2006, means that the product or part does not contain any of the following substances in excess of the following maximum concentration values in any homogeneous material: (a) 0.1% (by weight) for lead, mercury, hexavalent chromium, polybrominated biphenyls or polybrominated diphenyl ethers; or (b) 0.01% (by weight) for cadmium. unless otherwise stated by 3m in writing, this information represents 3ms best knowledge and belief based upon information provided by third party suppliers to 3m. in the event any product is proven not to conform with 3ms regulatory information appendix, then 3ms entire liability and buyers exclusive remedy will be in accordance with the warranty stated below. appendix c2: china rohs electronic industry standard of the peoples republic of china, sj/t11363-2006, requirements for concentration limits for certain hazardous substances in electronic information products. this symbol, per marking for the control of pollution caused by electronic information products, sj/t11364-2006, means that the product or part does contain a substance, as detailed in the chart below, in excess of the following maximum concentration values in any homogeneous material: (a) 0.1% (by weight) for lead, mercury, hexavalent chromium, polybrominated biphenyls or polybrominated diphenyl ethers; or (b) 0.01% (by weight) for cadmium. unless otherwise stated by 3m in writing, this information represents 3ms best knowledge and belief based upon information provided by third party suppliers to 3m. the numerical reference in the symbol above should not be construed as a representation regarding the products life or an extension of a product warranty. the product warranty is stated below. in the event any product is proven not to conform with 3ms regulatory information appendix, then 3ms entire liability and buyers exclusive remedy will be in accordance with the product warranty stated below. ria-2217b-d
important notice all sta tements, technical informa tion, and recommenda tions rela ted to 3m? s products are based on informa tion believed to be reliable, but the accurac y or completeness is not guaranteed. before using this product, you must evalua te it and determine if it is suitable for your intended a pplica tion. y ou assume all risks and liability associa ted with such use. an y sta tements rela ted to the product which are not contained in 3m? s current publica tions, or an y contrar y sta tements contained on your purchase order shall ha ve no force or effect unless expressly a greed upon, in writing, by an authorized of?cer of 3m. w arranty; limited remedy; limited liability . this product will be free from defects in ma terial and manufacture for a period of one (1) year from the time of purchase. 3m makes no o ther w arranties including, but no t limited to , any implied w arranty of merchant ability or fitness for a p ar ticular purpose. if this product is defective within the warranty period sta ted above, your exc lusive remed y shall be, a t 3m? s option, to replace or repair the 3m product or refund the purchase price of the 3m product. except where prohibited by la w , 3m will not be liable for an y indirect, special, incidental or consequential loss or damage arising from this 3m product, regardless of the legal theor y asserted. p l e a s e r e c y cle . p r i n t e d i n u s a . ? 3 m 2 0 0 8 . a l l r igh t s r ese r ve d . r i a - 2 2 1 7 b - d ? 3 m ele c t r o n i c s o l u t i ons d ivi s i o n 6 8 0 1 r i ve r p l ace b l v d . a u s t i n , t x 787 2 6 - 9 0 0 0 u .s. a . 1 - 8 0 0 - 2 2 5 - 5 3 7 3 www . 3 m . c o m / i n t e r c o n n e c t s 3m is a trademark of 3m compan y . ap p e n d ix c 3 : c hin a r ohs e l e c t r o n i c i ndu s t r y s t a n d a rd o f t he p eo p l e ? s r e p u b l i c o f c h i n a , s j / t 1 1 3 6 3 - 2 0 0 6 , r e q u i r e men ts f or c o n c e n t r a t i o n l i m i t s f o r c e r t a i n ha z a r d o u s s u b s t a n c e s i n e l e c t r o n i c i n f o r m a t i o n p r o d u c t s . thi s s ym b o l , p e r m a r k i n g f or t h e co n t r o l o f p o l l u t i o n c a u s e d b y e l e c t r o n i c i n f o r m a t i o n p r o d u c t s , s j / t 1 1 3 6 4 - 2 0 0 6 , m e a n s t h a t t he p r o d u ct o r p a r t d oe s c o n t a i n a s u b s t a n c e , as d e t a i l e d i n t h e c h a r t be l o w , i n e x c e s s o f t he f o l l o w i n g m a x i m u m c onc e n t r a t i o n v a l u e s i n a n y h o m o g e n eo u s m a te r i a l : (a) 0 . 1 % ( b y w e i g h t ) f or l e a d, m e r c u r y , h e x a v a l e n t c h r o m i u m, p o l y b r o m i n a te d b i phe n y l s o r p o l y b r o m i n a te d d i phe nyl e t h e rs ; o r ( b ) 0 . 0 1 % ( b y w e i gh t ) f o r ca d m i u m . u n l e s s o t h e r w i s e s t a te d b y 3 m i n wr i t i n g , t h i s i n f o r m a t i o n r e p r ese n t s 3 m ? s be s t k n o w l e d g e a n d be l i e f b as e d u p o n i n f o r m a t i o n pro v i d e d b y t hird p a r t y sup p l i e r s t o 3 m . t he n u m e r i c a l r e f e r e n c e i n t h e s ym b o l a b ove s h o u l d n o t be c o n s t r u e d as a r e p r ese n t a t i o n r e g a r d i n g t he p r o duc t ? s l i f e o r a n e x te n s i o n o f a pro d u c t w a r r a n t y . t h e p r o duc t w a r r a n t y is s t a te d be l o w . i n t h e e v e n t a n y pro d u c t i s p r o v e n n o t t o c o n f o r m w i t h 3 m ? s r e g u l a t o r y i n f o r m a t i o n a p p e n d i x , t h e n 3 m ? s e n t i r e l i a b i l i t y a n d b u y e r ? s e x c l u s i v e r e m e d y w i l l be i n a c c o r d a n c e w i t h t h e p r o d u c t w a r r a n t y s t a te d be l o w .
|
